产品名称：硬齿面减速机产品类别：ZDY80-1.4-1减速机产品规格：ZSY80减速机、一、概述型号：ZDY80-1.4-1减速机重量：24公斤类型：硬齿面减速器，ZDY减速机主要包括平行轴系列和垂直轴系列．平行轴减速器是按***标准(JB／T8853—200。1)生产，产品经优化设计。具有国际八十年代***水平，它主要包括ZDY(单级)、ZLY(两级)、ZSY(三级)和ZFY(四级)四大系列，垂直轴减速器是按***标准(』B／T9002—1999)生产．用于输入轴与输出轴呈垂直方向布置的传动装置．它主要包括DBY、DCY和DFY三大系列；1．性能特点(1)中心距．公称传动比等主要参数均经优化设计，主要零、部件—里换性好(2)齿轮均采用优质合金钢经渗碳、淬火而成．齿面硬度达54～62HRC(3)体积小、重量轻、精度高、承载能力大、效率高，寿命长，可靠性高、传动平稳、噪声低。(4)一般采用油池润滑．自然冷却，当热功率不能满足时，可采用循环油涧滑或风扇。冷却盘管冷却。2、应用范围(1)输入转速一般n、≤1500r／min．(2)齿轮传动圆周速度不大于20mis。(3)工作环境—40_50~'C．如果低于0℃．启动前润滑油应预热至0℃以上。本减速器可用于正反两个方向运转。(4)可广泛用于冶金、矿山、化工、建材、起重、运输、纺织、造纸、仪器、塑料、橡胶、工程机械、能源等工业部门。二、选用方法1、已知参数和条件原动机名称，功率P1=kW转速n1=r／min工作机名称，功率P2=kW转速n2=r／min要求的传动比i=n、／n，每天工作小时数h，每小时启动次数次，每小时运转周期％．负荷特点(平稳、冲击、严重冲击)．可靠度要求(一般、较高、高)环境温度℃，现场散热条件，冷却水温度℃联轴器型式．齿轮轴轴伸上是否还要承受其他附加力装配方式型，输出轴旋向(双向旋转时请说明主旋向)有无其他特殊要求2、按额定功率选择规格型号平行轴系列齿轮箱的公称输入功率P。(表9—20)按载荷平稳，每天工作时间小于或等于10h，每小时启动不超过5次．允许启动转矩为工作转矩的2倍。单向运转，单对齿轮的接触强度安全系数约为1，失效概率小于或等于1％等条件计算确定的，，齿轮箱双向运转时．需视情况将PA乘上0．8—1．0的系数，当反向载荷大，换向频繁、选用的可靠度系数K。较低时．系数取较小值．反之取较大值，、所选齿轮箱的额定功率必须满足：P(：二P：KAK；K。≤PA式中：Pc—计算功率P2—工作机功率KA—使用系数．KS—启动系数KR—可靠度系数3、按许用热功率校核平行轴系列齿轮箱的许用热功率P，适用于环境温度20C．每小时100％连续运转和功率利用率(P2／P1·100％)为100％的情况，条件不同时须进行修正。三、ZLY硬齿面减速机外形安装图：了解详细规格及基本参数详情规格ABH=ai=1.25-2.8i=3.15-4.5i=5-5.6d1(m6)l1L1b1t1d1(m6)l1L1b1t1d1(m6)l1L1b1t1802351502108028421128312436106827192898621.51002901752601004282167124528421278312236121624.5125355195330125048821821451.538581581041284214283116044524540316065105225186948822021451.53858178104120054531050720080130275228560105250186448822271451.52506803706622501001653402810680130305228560105280186428075545072228011016538528116851303502290651053251869315840500770315130200445321379513037525100751053502079.53559305509303551402004703614810016543528106901304002595400104060598240015020048536158110165450281169513041525100450115064510904501602405454016912016547032127100165470281065001290710127050018024058045190130200540321371201655053212756014407801360560200280660452101502005803615813020058032137规格d2(m6)l2L2b2t2cm1m2m3n1n2e1e2e3h地脚螺栓孔重量Kg润滑油量Ld3n803258128103518180--120406067.581101100124140.910048821671451.522225--14052.572.585102122125154351.61255582182165925290--1606510097.5119155160154763.2160701052252074.532355--2007312211814119020018.541156.520090130275259540425--2558014514016923525024422812.52501101653402811650550275305110190175214295315286400232801302004203213750620310380120220187.5228328355286540363151402004453614863700350420137.5247.5207.5254364400356800453551502004703615863770385470142.5272.5222.52693974503568707040016024052540169808504255101503002453044545004261640904501702405454017980950475550165335265331501560426210012550019028062045200100108054061019039029541861863042631001805602403307905625210012006006802054353254326627104863730250ZDY减速机输入功率表公称转动比i转速r/min规格输入n1输出n280100125160200250280315350400450500560公称输入功率PAKW15001200571032053606331121---------------------1.2510008004069140260446807---------------------7506003152105190348636---------------------1500107053961943266161109---------------------1.410007153765132240433794---------------------7505352948102180337624---------------------150094049921803105871068147319962766------------1.610006253463125217410760105114301992------------75047027509816831959582411241569------------150083545871732905571024141119252663------------1.810005553162120206389726100213721906------------75041524489516030256778410721497------------15007503980158278526970133918272536------------21000500275511019436768494612961806254735784793---75037521438515028453473810131414199928213775516915006703670141264484914123617112377------------2.24100044525499818333764587412071683240233974512---7503351938761422625036829411314187826673538483315006003264127245447885115416172264------------2.5100040022458817031160181211361596223531824353---7503001735681322414686338841243174224923406464515005352753115224409789106314892068------------2.8100036019378015528455274610481456204929454000---7502701529621202204295808161134159322963118423215004752347962033757099901359192426583790503666663.151000315163367140260496695952135218172681360748077502351325521092023855407401052145820842802374715004252041851793376398981210173024103407446061193.55100028014285912423444662884512101694239631904395750210112246961813464886559401312185624833419150037517346915530057077410951555214629813985565141000250122448107)