脱色树脂泵表面漆树脂泵有机硅胶泵高粘度泵咨询电话：13610186785常经理合型树脂用NYP50-V-W4内啮合高粘度泵聚氨酯树脂输送用NYP220-V1-W4内转式高粘度泵丙烯酸树脂输送专用泵NYP110-V-W4内转式齿轮泵氨基树脂输送泵用NYP80-V-W1内啮合高粘度泵酚醛树脂输送用NYP50-V1-W1高粘度泵松香树脂NYP110-V-W4不锈钢保温高粘度泵呋喃树脂输送泵NYP50-V-W4不锈钢保温内啮合高粘度泵脲醛树脂输送用NYP80-V-W1保温高粘度泵脱色树脂输送泵用NYP内转式样齿轮泵螯合树脂NYP内啮合齿轮泵惰性树脂用NYP7.0-V-W4不锈钢内啮合高粘度泵表面漆树脂用NYP保温内啮合高粘度泵原子灰树脂用NYP730不锈钢内啮合高粘度泵仿木树脂NYP320-V1-W1保温高粘度泵环氧树脂用NYP80保温高粘度泵聚酯树脂专用NYP内转式齿轮泵丙烯酸树脂输送用NYP内啮合高粘度泵离子交换树脂输送用NYP内啮合高粘度泵不饱和聚酯树脂输送泵用NYP110-V-W4高粘度泵聚酰胺树脂NYP内转式齿轮泵有机硅树脂NYP内啮合高粘度泵聚碳酸酯共聚物NYP220-V1-W1保温内啮合高粘度泵天然树脂NYP不锈钢高粘度泵酮醛树脂NYP110-V-W1不锈钢内转式齿轮泵催化树脂NYP50-V-W4不锈钢保温高粘度泵吸附树脂NYP内转式齿轮泵钮扣树脂NYP110-V-W4不锈钢内转式齿轮泵人造石树脂输送用NYP内啮合齿轮泵PE树脂输送用NYP保温高粘度泵柔性树脂输送用不锈钢高粘度泵107胶硅橡胶输送泵NYP730-T-W1保温高粘度泵典型应用■化工石化：石油，添加剂，聚合物，润滑油，油，蜡，沥青，松香，纤维，粘胶，乙醇，淀粉，液氨，蜡，胶水，清洁剂，油脂，乳胶，树脂，皂液，香波，硅油，化学流体，高粘度流体■油漆涂料：油墨，墨水，染料，油漆，溶剂，油墨，橡胶溶液，粘胶，乳胶，水性漆，溶剂漆，溶剂，油墨（丙烯酸涂料，水性涂料，溶剂性涂料）磁性漆，凡立水，绝缘凡立水，乳剂■塑料聚酯：聚酯，环氧树脂，硬化剂，异氰酸酯，缓和剂，树脂，表面活性剂，胶水，油脂，树脂类，聚合体溶剂，表面活性剂，合成树脂，粘结剂，浆糊，墨水，胶乳，塑料，多氯三苯树脂，丙烯酸树脂，不饱和聚酯树脂，醇酸树脂，苯酚树脂，三聚氰胺树脂，聚亚安脂，聚苯乙烯，AS树脂，ABS树脂，环氧树脂，乙烯基醋酸，人造革，聚合体溶剂■纸浆造纸：胶水，粘合剂，黑液，烧碱，黏胶，油漆，纤维■日化行业：磺酸，烷基苯，脂肪醇，洗涤剂，剃须膏，面霜，洗发精，皂液，面霜，香精，香波，皂液，洗涤剂,洗涤剂，剃须膏，面霜，洗发精，皂液■食品行业：植物油，卵磷脂，糖浆，巧克力酵母，蛋白，蜂蜜，甘油，香精，乳酪，黄油，香料，植物油，油脂，葡萄糖，果酱，葡萄酒，动植物油，食用油，豆油，菜籽油，玉米油，糠油，维他命油，猪油，牛油脂，黄油，人造黄油，巧克力，果子冻，肉肠，咖哩糊，果酱，蜜糖，糖浆，冰激凌，果糖，鱼肉，宠物食品,糖浆，蜂蜜，果酱，调料，奶制品。■化纤行业：粘胶、烧碱、染料■设备成套：聚脂设备，巧克力设备，润滑油循环，印刷机械，沥青机械，沥青车■冷库：液氨，氟利昂■造船：燃油，消防泡沫，重油，原油，润滑油，基础油，液压油备注：内啮合高粘度泵选型很重要，“选好泵是用好泵的基础”，根据客户使用的工况不同，高粘度泵选型配套不一样。欢迎拨打24小时热线服务电话：13610186785常工程师指导选型。高粘度泵,高粘度转子泵,沥青输送泵,树脂泵●概述NYP高粘度泵(高粘度转子泵,沥青输送泵,树脂泵)是一种容积式内转子泵。这种类型的泵自吸性能强，适用于输送不含固体颗粒和纤维的粘稠液体，甚至是半固体状态的液体，最高输送粘度达到3*105厘泊。具有体积小、重量轻、脉动小、噪音低、运转平稳、寿命长等优点。该型泵可广泛用于石油、化工、颜料、化工、颜料、食品、肥皂、洗涤剂及制药等行业。●工作原理该高粘度泵(高粘度转子泵,沥青输送泵,树脂泵)具有内齿的主动齿带动内转子在全封闭的泵体内作同方向转动，泵壳和月牙板使吸入口和排出口隔开，转动时，在吸入口形成负压，液体被吸入，被转子带到排出口，受压排出泵体，完成了液体的输送。●结构特性NYP高粘度泵(高粘度转子泵,沥青输送泵,树脂泵)采用外部润滑方式。轴承部分和泵腔工作部分由密封部分隔开，轴承部分可通过油杯从外部定期加油润滑。泵体内设有加热或冷却夹套，可通过外部装置实现加温或降温过程。该型泵可配安全阀，当泵或管路系统超压时，安全阀打开，形成内部回流，保证系统安全。泵有泵体、泵盖、安全阀部分、主动轴、内、外转子、支座、轴承等部分组成。泵装置由泵、电机和底座组成。泵和电机固定安装在底座上，传动方式有皮带传动和联轴器直联两种方式。●NYP高粘度泵(高粘度转子泵,沥青输送泵,树脂泵)使用时注意事项1、进、出口管路的管径必须和泵保持一致；2、设计管路时应尽量减少弯头，且弯头角度不宜过小，进口管线不宜过长，以免影响自吸。3、启动前每个注油杯都应家润滑油，且保证每天加油一次。4、泵在工作前应该点动启动电机，观察转向是否和规定转向一致。5、开机后观察运转是否正常，如有不正常噪音、特殊振动或温升过高等情况，应停机检查。6、注意皮带松紧是否恰当，每半年调整一次********************************************************************联系人：常用联系电话：13610186785办公电话：020-82375311业务传真：020-82375311业务QQ：286090495e-mail:changyong_9527@**********************************************************远东泵业公司旺铺：http://.●NYP高粘度泵性能参数表性能参数Performancedata型号model通径NominalSizemm理论排量DisplacementL/100rev粘度ViscoityCst转速SpeedR/min压差DifferentialPressure(Mpa)连接形式Connection0.40.60.81轴功率Power(kw)流量Capacity(L/min)轴功率Power(kw)流量Capacity(L/min)轴功率Power(kw)流量Capacity(L/min)轴功率Power(kw)流量Capacity(L/min)NYP0.78150.782013900.179.30.2390.288.80.328.6螺纹Thread6013900.189.50.249.20.2890.338.920013900.3110.40.3510.20.39100.439.960013900.3910.40.4410.30.4810.30.5210.220009100.236.80.276.80.36.80.336.760007200.245.40.316.10.386.80.46.8NYP2.3252.32014000.3828.40.4927.5螺纹Thread6014000.5929.20.6528.820014000.61300.7229.660014000.9231.90.9631.720009100.6119.90.6819.760007200.7716.320.8316.2NYP3.6403.62014500.6946.70.9445.91.18451.4443.4法兰Flange6014500.8147.51.0946.71.3745.91.5744.720014501.0649.71.3149.21.5648.81.7948.360014501.4549.91.6149.61.7749.31.934920009601.28341.4133.81.5433.71.6533.660006401.08231.1822.91.2822.91.3722.8200005831.2220.51.2420.41.2520.41.3820.3600004550.8416.30.9116.20.9816.11.0116NYP7.0NYP7.0A40702014501.3698.11.896294.72.493螺纹Thread6014501.45991.9972.296.42.69520014501.6299.82982.397.52.7976009601.4621.6651.864.526420009601.8672662.3652.66560006401.544.51.7441.844244200005831.640.51.9402.1402.240600004551.4631.51.8311.931231NYP245024207201.81652.31612.81583.4155法兰Flange6072021662.61643.11623.71582006101.91432.514131393.51366005412.11272.612531243.512220004752.21122.61112.91103.410960003572852.3842.6832.983200003031.9722.2722.4722.671600002281.6541.8542542.354NYP50NYP50A5050207204.33625.83556.93488.1340螺纹Thread607204.73646.23587.33527.53462006104.63095.93046.930082946005414.927562716.82687.8264200047552435.92386.62377.623560003574.11844.91825.31816.2180200003033.81574.61565.11555.6155600002283.11193.711841184.5118NYP808080206155.24716.94618.545110433法兰Flange606155.54747.24658.845710.54482005445.74217.24148.640810.140160047963727.33678.53629.835620004176.53267.73228.931910.131560003055.62396.62377.53268.4233200002285.51806.41796.91787.7177600001885.51496.11496.71497.2148NYP110NYP110A80110206156.76609.264711.263413.6622法兰Flange606156.96649.465211.564213.96312005447.15899.35801157313.25636004797.35219.551411.150813.150220004177.74559.74501144712.744260003056.93358.43329.433110.6328200002286.32517.52508.22499.2248600001886.22097.12087.62088.5207NYP160100160206008.993012.191615.390217.5888法兰Flange606009.493512.692215.89101989820055012.386615.385918.385221.384560048010.275412.874715.47401873720003559.156011.15561355215.154860003191050511.750213.550015.2497NYP220100220204308.890211.98801585818836法兰Flange6043099091289015871188522003558.575311.173913.772616.37316003209.468211.867114.166016.564920002549.1544115371353015.1523600024410.148311.947813.647315.4468200001609.134710.534511.934313.3341600001178.42569.425510.425411.4253NYP32010032020430131306181270221235261200法兰Flange6043013131618.5128522125526.5122520035511.8109115.5106819.1104622.8102460032013.298716.596819.795022.9932200028414.288117.486720.685423.8841600022213.769316.268418.767521.26662000016813.252915.352517.352219.4519600001251239713.739615.339516.9394NYP4401504402021012.6128017.31238221196法兰Flange6021013.3129317.6125722.1122120018911.9117016118020.3111160016811.7104815.1102319.31000200013011.381713.780116.3784600010610.767213.266215.165220000789.074971149212.848360000661043011.542913427NYP650)